Studi Pengaruh Abu Batu Bata terhadap SifatFisik dan Mekanik Lempung Terstabilisasi Kapur dari Kecamatan Tenayan Raya

Authors

  • Soewignjo Agus Nugroho Universitas Riau
  • Ferry Fatnanta Universitas Riau
  • Giri Prayoga Universitas Riau

DOI:

https://doi.org/10.35134/jcivil.v6i1.18

Keywords:

Clay, Swelling, Lime, Brick ash, Soil bearing capacity

Abstract

Tenayan Raya Subdistrict is an area that has a thickness of soft clay layer. Some cases of building failure were cracks and tilts due to high shrinkage of soil. Nearby is also a brick home industry center, where ashes are produced from bricks burning. Soil Improvement of Tenayan-Raya's Clay and utilization of brick ash will be carried out in this research. This study aims to stabilize the soil with lime and utilize the brick ash to improve shear strength and bearing capacity of the soil. The study was conducted in the laboratory by making several combinations of content clay, lime, and Brick Ash (BA), for the soil mixture which will be added with 10% ash brick. The effect of curing and soaked will also be seen for its rising on soil properties of Unconfined Compression Strength, and CBR laboratories. The influence of water will also be reviewed on the dry side, optimal moisture content, and wet side. The test results show that the Soil has Low Plasticity soil type category CL-ML symbols, according to the Unified classification. Increasing of strength due to stabilization with lime is obtained in conditions of water in optimal moisture content, where the addition of lime is 10% and 10% brick ash, was produced to increase the maximum value of Unconfined Compression Strength and CBR laboratory value. Curing setup time and saturation (soaked) also had affect the value of Unconfined Compressive Strength and CBR laboratory test. At longer time for curing, shear strength will rise proved by the value of UCS Test and
bearing capacity value also increase that can be seen of the laboratory CBR test. Curing will make the shrinkage of clay reduced, this can be proven from differences value of Unconfined Compressive strength test between samples with and without soaked, are relatively small. 

References

Adha, I., 2009. Pengaruh Resapan Air (Water Adsorption) Terhadap Daya Dukung Lapis Pondasi Tanah Semen. Jurnal Rekayasa. Vol. 13. Universitas Lampung. Bandar Lampung

ASTM D-2488, 1990, Practice for Description and Identification ofSoils (visual manual procedure).

Budi, Gogot Setyo, Denny, Setiawan Ariwibowo, Agus Terisna Jaya, 2002, Pengaruh Percampuran Abu Sekam Padi dan Kapur Untuk Stabilisasi Tanah Ekspansif. Dimensi Teknik Sipil 4 (2), 94-99, Universitas Kristen Petra.

Caunce, C. M., 2010, Effective Road Pavement Design for Expansive Soils in Ipswich. Bachelor of Engineering (Civil). University ofSouthern Queensland, 15-18

Eric Berger. 2007, Lime Use for Soil & Base Improvement (Application Design Testing), „Chemical Lime‟, A Lhoist Group Company

Holtz, R. D. dan Kovacs, W.D., 1981.An Introduction to Geotechnical Engineering. Prentice-Hall, Englewood Cliffs, New Jersey

Holtz, W.G., Gibbs, H.J., 1959, Engineering Properties of Expansive Clays, ASCE Journal.

Ingles, O. G., Metcalf, J., B., 1972, SoilStabilizationPrinciples and Practice, Butterworths, Sydney.

Jon A. Epps, Wayne A. Dunlap, Bob M. Galloway, 1971, Basis for the Development of a Soil StabilizationIndex System”. Reproduced by National Technical Information Science, Springfield, 2.

Lambe, William T., 1962, Soil Stabilization, Foundation Engineering. G.A. Leonard. McGraw-Hill. NewYork.

Marshall, R. Thompson, 1967, Factor Influencing the Plasticity and Strength of Lime-Soil Mixtures, TheBoard of Trustees of the University of Illinois.

Metcalf, J., B., 1959, A laboratory investigation of the strength age relations of fine soil stabilized with whitehydrated lime and ordinaryPortland cement. RN/3435/JBM.DSIR RRL. March, 1959

Agus Nugroho, S., Ika Putra, A., & Yusa, M. (2018). STUDY GRADATION AND MOISTURE CONTENT OF SAND EMBANKMENT ON PEAT SUBJECTED VIBRATION POTENTIAL LIQUEFACTION.

In IOP Conference Series: Materials Science Engineering (Vol. 316, pp. 1–7).

M.Shoffar Al Hafizh, Wibisono, G., & Agus Nugroho, S. (2017). Stabilisasi tanah lempung dengan pasir bermacam gradasi dan campuran kapur. JOM FTEKNIK Universitas Riau, 4, 1–9.

Muhardi, Nugroho, S. A., & Ningrum, P. (2014). Perubahan Nilai CBR Pada Kadar Air OptirnumBasah Carnpuran Tanah Lernpung Dan Abu Terbang. In the 18th Annual National Conference on Geotechnical Engineering (pp. 199–206).

Nugroho, S. A. (2012). Riau Peat Stabilization Using Mix Non-Organic Soil and Cement as Road Fills.

Dinamika Teknik Sipil, 12(2), 151–156.

Nugroho, S. A., Fatnanta, F., & Iqbal, M. (2014). Penambahan Pasir dan Kadar Air Pada Sisi Basah Terhadap Nilai CBR pada tanah Lempung. In 18th Annual National Conference on Geotechnical Engineering (pp. 243–250).

Nugroho, S. A., Ika Putra, A., & Ermina, R. (2012). Korelasi Parameter Kuat Geser Tanah Hasil Pengujian Triaksial dan Unconfined Compression Strength (UCS). Jurnal Sains Dan Teknologi, 11(1), 1–10.

Nugroho, S. A., Satibi, S., & Fatnanta, F. (2012). Effect of Clays Fraction to California bearing Ratio Laboratory Test Value with and without soaked. In GEOMATE Proceeding 2012 (pp. 131–136).

Nugroho, S. A., Satibi, S., & Fatnanta, F. (2012). Effect of Clays Fraction to California Bearing Ratio Laboratory Test Value with and Without Soaked. In 2nd International Conference on Geotechnique, Construction Materials and Environment (pp. 131–136).

Nugroho, S. A., Suratman, & Pratama, D. (2017). Kajian Rentang Kadar Air Terhadap Nilai Kuat Geser Perbaikan Sirtu Dengan Metode CTB. In KoNTekS 11 (pp. 47–54).

Nugroho, S. A., Wibisono, G., & Kasbi, F. (2013). Analisa Peningkatan Kekuatan Tanah Yang Diperkuat Serat dan Bahan Stabilisasi pada Sisi Kering dan Sisi Basah. Jurnal Teknik Sipil, 12(2), 137–144.

Nugroho, S. A., Wibisono, G., & Umam, K. (2016a). Effect Gradation and Clay Content on Shear Strength of Clayey Sand. In Sriwijaya International Conference on Shear Strength of Clayey Sand (pp. 59–62).

Nugroho, S. A., Wibisono, G., & Umam, K. (2016b). Shear Strength Study Effect of Gradation and Clay Content on Clayey Sand. In Sriwijaya International Conference on Engineering, Science & Technology(pp. 59–62).

Nugroho, S. A., & Yusa, M. (2012). Prediction for CBR Unsoaked Value to CBR Soaked Value and Index Properties of Clay-Sand Mixture of Pekanbaru Soils. In 8th International Symposium on Lowland Technology (pp. 59–65).

Umam, K., Nugroho, S. A., Wibisono, G., (2017), Pengaruh gradasi pasir dan kadar lempung terhadap kuat geser tanah 1, Jurusan Teknik Sipil, Fakultas Teknik, Universitas Riau, Pekanbaru 4(1).

Wibisono, G., Agus Nugroho, S., & Umam, K. (2018). THE INFLUENCE OF SAND‟ s GRADATION AND CLAY CONTENT OF DIRECT SHEART TEST ON CLAYEY SAND. In IOP Conference

Series: Materials Science and Engineering (Vol. 316, pp. 1–8).

Verhoef, P.N.W, (1994) Geologi Untuk Teknik Sipil. Erlangga, Jakarta

Warsiti, 2009, Meningkatkan CBR dan Memperkecil Swelling Tanah Sub Grade Dengan Metode StabilisasiTanah dan Kapur, Jurnal Polines, 14 (1), Semarang:

Winterkorn, H. F., 1957, Granulometric and Volumetric Factors in Bituminous Soil Stabilization,Proceedings Highway Research Board, 195.

T. Herawan, M.M. Deris, and J.H. Abawajy, “A Rough Set Approach for Selecting a Clustering Attribute,”Knowledge Based Systems, Volume 23, Issue 3, 220231, 2010.

Downloads

Published

2021-04-30

How to Cite

Nugroho, S. A. ., Fatnanta, F. ., & Prayoga, . G. . (2021). Studi Pengaruh Abu Batu Bata terhadap SifatFisik dan Mekanik Lempung Terstabilisasi Kapur dari Kecamatan Tenayan Raya. Civil Engineering Collaboration, 6(1), 17–23. https://doi.org/10.35134/jcivil.v6i1.18

Issue

Section

Articles